CHBMJ - MOLYTEX (A), 1050
- MSDS: CHBMJ
- Manufacturer: RAMCO SPECIALTY PRODUCTS
- Product Name: MOLYTEX (A), 1050
- National Stock Number: 9150-00N085357
Product Identification
Product ID:MOLYTEX (A), 1050
MSDS Date:07/10/1997
FSC:9150
NIIN:00N085357
MSDS Number: CHBMJ
Responsible Party
ANAHEIM, CA 92806-5619
US
Emergency Phone: 800-255-3924
Info Phone: 800-334-7071
Preparer: LINDA SUE SHEPHERD
Cage: 0AV13
Contractor
Telephone: 714-758-7795/800-334-7071
Cage: 0ZUM2
Ingredients
METHYLENE, DICHLORO-; (METHYLENE CHLORIDE) (SARA 313)
CAS: 75-09-2
RTECS: PA8050000
OSHA PEL 500 PPM; Z-2
ACGIH TLV: 50 PPM, A2; 9495
EPA Report Quantity: 1000 LBS
DOT Report Quantity: 1000 LBS
VM & P NAPHTHA; (PETROLEUM DISTILLATE)
CAS: 64742-89-8
OSHA PEL 400 PPM (MFR)
ACGIH TLV: 400 PPM (MFR)
LPG (LIQUEFIED PETROLEUM GAS)
CAS: 68476-85-7
RTECS: SE7545000
OSHA PEL 1000 PPM
ACGIH TLV: 1000 PPM; 9495
Hazards
LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:CHLOROCARBON MATERIALS HAVE PRODUCED
SENSITIZATION OF THE MYOCARDIUM TO EPINEPHRINE IN LABORATORY
ANIMALS AND COULD HAVE A SIMILAR EFFECT IN HUMANS. ADRENOMIMETICS
(EG, EPINEPHRINE) MAY BE CONTRA-INDI CATED EXCEPT FOR
LIFE-SUSTAINING USES IN HUMANS ACUTELY/CHRONICALLY EXPOSED TO
CHLOROCARBONS . (EFTS OF OVEREXP)
Explanation of Carcinogenicity:METHYLENE CHLORIDE: IARC MONOGRAPHS
SUPPLEMENT, VOLUME 7, PAGE 194, 1987: GROUP 2B. NTP 7TH ANNUAL
REPORT ON CARCINOGENS, 1994: ANTICIPATED TO BE CARCINOGEN. ANIMAL:
LUNG, LIVER, SALIVARY, MAMMARY GLA ND (TUMORS).
Effects of Overexposure:HLTH HAZ:EYES: MAY CAUSE SLIGHT IRRIT BUT DOES
NOT INJURE EYE TISSUE. INGEST: CAN CAUSE GI IRRIT, NAUS, VOMIT &
DIARR. ASPIR INTO LUNGS CAN CAUSE CHEM PNEUMONITIS. MINIMAL TOX.
INHAL: MIST CAN CAUSE I RRIT OF NASAL & RESP PASSAGES.
ABUSIVE/EXCESSIVE INHAL MAY CAUSE IRRIT TO THE UPPER RESP TRACT,
DIZZ, NAUSEA, AND OTHER CNS EFFECTS. SKIN: FREQUENT OR PROLONGED
CONTACT MAY CAUSE IRRITATION.
Medical Cond Aggravated by Exposure:NONE KNOWN.
First Aid
First Aid:EYES: FLUSH W/LRG AMTS OF H*2O USING EYECUP/FOUNTAIN FOR A
LEAST 15 MINS WHILE HOLDING UPPER & LOWER LIDS OPEN. SEEK MED ATTN
IMMED IF IRRIT PERSISTS. INGEST: DO NOT INDUCE VOMIT. SEEK MED ATTN
IMMED. INHAL: REMOVE TO FRESH AIR. SEEK MED ATTN IMMED. IF
BREATHING STOPS GIVE ARTIFICIAL RESPIRATION. SKIN: REMOVE
CONTAMINATED CLOTHING. WASH W/SOAP & WATER. SEEK MEDICAL ATTENTION
IF IRRIT PERSISTS.
Fire Fighting
Flash Point:80.0F,26.7C
Extinguishing Media:FOAM, CO*2, DRY MEDIA.
Fire Fighting Procedures:WEAR NIOSH APPROVED PRESSURE DEMAND SCBA AND
FULL PROTECTIVE EQUIPMENT . COOL FIRE EXPOSED CONTAINERS TO PREVENT
RUPTURING.
Unusual Fire/Explosion Hazard:THERMAL DECOMPOSITION PRODUCTS MAY
INCLUDE HCL AND PHOSGENE . EXPOSURE TO TEMPERATURES ABOVE 120F. MAY
CAUSE BURSTING.
Accidental Release
Spill Release Procedures:ALLOW PROPELLANT TO EVAPORATE. MAINTAIN LOC
EXHST & ADEQ VENT. NO SMOKING. KEEP SPARKS, HEAT SOURCES & OPEN
FLAME FAR AWAY FROM SPILL/LEAK. COVER W/ABSORB MATL & SWEEP UP.
WASH AREA TO PVNT SLIPPING. DISPOSE OF SOAKED ABSORBENT MATL IN
ACCORDANCE WITH ALL LOCAL, STATE, AND FEDERAL REGULATIONS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.
Handling
Handling and Storage Precautions:STORE IN A COOL DRY AREA AWAY FROM
HEAT, OPEN FLAME, OR AT TEMPERATURES ABOVE 120F. NFPA CODE 30B
RATING - LEVEL 3 AEROSOL.
Other Precautions:NO SMOKING IN AREA/USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES/HOT SURFACES. HEAT &/UV
RADIATION MAY CAUSE THE FORMATION OF HCL &/PHOSGENE . KEEP OUT OF
REACH OF CHILDREN - FOR INDUS & INSTITUTIONAL USE ONLY.
Exposure Controls
Respiratory Protection:NONE NEEDED FOR PROPER USE IN ACCORDANCE WITH
LABEL DIRECTIONS. NIOSH APPROVED RESPIRATOR APPROPRIATE FOR
EXPOSURE OF CONCERN .
Ventilation:PROVIDE LOCAL EXHAUST TO KEEP TLV OF SECTION 2 INGREDIENTS
BELOW ACCEPTABLE LIMITS.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS .
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA .
Work Hygienic Practices:NONE EXCEPT USUAL PRECAUTIONS - WASH HANDS WITH
SOAP AND WATER BEFORE EATING.
Supplemental Safety and Health
Chemical Properties
Boiling Pt:B.P. Text:>92F,>33C
Vapor Pres:62 PSIG
Vapor Density:>1
Volatile Org Content %:35
Spec Gravity:1.195 @75F (H*2O=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:DARK GREY VISCOUS LIQUID; SOLVENT ODOR.
Stability
Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:HCL, PHOSGENE . CARBON DIOXIDE, CARBON
MONOXIDE.
Disposal
Waste Disposal Methods:AEROSOL CANS, WHEN EMPTIED AND DEPRESSURIZED
THROUGH NORMAL USE, POSE NO DISPOSAL HAZARD AND SHOULD BE RECYCLED.
CONSULT LOCAL, STATE AND FEDERAL AUTHORITIES FOR APPROVED
PROCEDURES.
Other Information
Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.